Miller Magazine Issue: 153 September 2022

66 COVER STORY MILLER / SEPTEMBER 2022 til the top-elevator with being brandished and spilled to the exit point during the turning around the driven drum. 1.1.PADDY CLEANER Although the grain cleaning machine is generally de- signed for paddy, it can be used in other pulses ma- chines by changing the sieve numbers. Paddy, rice and so on. cleaning of legumes, separation of foreign materials (garbage, millet, powder straw, etc.) The machine cleans the fine products in the product with air aspirator. It can produce two sizes of sieve. The machine can be used for pre-cleaning of dry or wet grain products. The product poured into the feed bunker of the ma- chine is transferred to the next stage with flow pipes after cleaning. The product starts to be scattered by means of vibration method on the sieve. Garbage and dusts that are lighter than paddy are separated from the paddy by the aspirator. According to the size of the sieve pre-installed on the machine, the product passes under the sieve and starts sieving from the bottom sieve. If it is thinner than paddy under the bottom sieve, small and heavy particles fall off. The product remaining on the low- er layer is poured into the second sieve table to be separated again. At the same time, the light items which are left in three of the products are sucked and cleaned to separate them again with the aspirator. On the second sieve plate, the product passes over again. The separated product is dispatched from the clean product outlet bin. 1.2 DESTONER Destoner machine; It is used for cleaning from stones, sand and soil inside dry granular agricultural products such as rice and paddy. The product en- tering the entrance of the stone separator is poured into the sieve of the machine. The vibration creat- ed by the eccentric system and the product air are floated on the sieve with the effect of air from below and vacuum air from above. Heavy materials (stone, soil, sand, etc.) are scratched upwards on the sieve with the vibration of the sieve table. The product we want to break down goes down because it is lighter. Through this process, stone, soil, sand, it is separated from the materials. 1.3 PADDY PEELER It was developed for the ones who desire a com- bined machine which has got high capacity in the paddy processing plants. The paddy husker and the husk aspirator which are combined have got a very important place about the plants to modernize themselves with more production capacity, less place covering, less electric consume and low care expens- es. Glume aspirator with paddy husker is a machine which husks the cover of the paddy and separate the glume and the rice from each other’s in the paddy processing plants. It husks the cover of the glume aspirator with paddy husk- er while it moves among the mangles which are covered with rubber turning in different circuits from each other in opposite sides. The husked mixture (paddy, rice, dandruff and glume) are powered on an eccentric system. The distin- guished mixture on the sieve enters into the aspirator reser- voir of the machine and distinguished from each other’s in the air channels and exists from the machine beside being transported to different flows. The feeding bunker has sen- sor, when bunker is full with product machine start to work. When feeding bunker becomes to empty machine stop. When the machine starts; it distributes the paddy which is on the electromagnetic vibro product distributor to the husking mangles. The paddy which moves through the